Some good ways to recondition the batteries at a golf cart

This is because the discharge procedure tends to leave a deposit onto the plates of the battery, and trapping them promptly will cause this particular deposit to dissolve.

The Process

Though the reconditioning process works on a fantastic majority of batteries, there will always be the odd one out that the reconditioning process doesn’t operate upon.

After this, you need to charge the battery generally, as you do, but allow it to stay charging for around twelve hours. A high amperage current during this approach is suggested.

You are likely going with lead acid batteries, as only these can set out the quantities of electricity that are essential at a reasonable price.

If total sulfation has happened, this acid should be feeble, but it may still be extremely corrosive, so be careful to not spill it on any sensitive surface, and not on your skin or eyes.

When a battery is simply restored partially, and you find you cannot use it in a golf cart, simply keep in mind that lead-acid batteries can also be utilized in solar electricity systems, in addition to in power backup systems.

But any delay in charging the battery signifies the deposit can liquefy on the plates of the battery, completely destroying the battery. So remember that – you need to recharge to one hundred percent just as quickly as possible after the battery releases.

If you have golf carts, you understand what a fiscal strain it is if their batteries fail and must be replaced.

It is more preferable to purchasing a new battery, and it will cost a fraction of what a new battery will cost you. The reconditioning procedure itself is not difficult. All you have to do is pour the acid in cells out , and open up the cells of the battery.

Protective gloves are a must, as are protective goggles.

After about twelve hours or so, permit the battery to discharge completely and then charge it again, and at this point the battery should be reconditioned and ready to use again.

Let’s first discuss how best to keep the batteries in your golf cart, so as to prevent issues with them in the first place.

You might find that the cart gets quite sluggish.

One thing that you need to remember about lead-acid batteries is that you ought to maintain them in a full charge as far as possible. This does not imply that you can not use them, needless to say, it just means that you must recharge them to one-hundred percent when possible after releasing.

Now, take 2 liters of distilled water, bring it to boiland add in about two hundred and fifty grams of calcium sulfate, which is also known as Epsom salt. Close the battery’s tissues and let it stand for a few hours to ensure the Epsom salt mixture can strike the sulfate and dissolve it.

Now, it is only a matter of treating the tissues of the battery, that is to say, of reconditioning them.

What you might not know is that it’s possible to recondition these batteries and reunite them to operational condition fairly cheaply.